Nieco JF62 Manuale Utente

WA R N I N G :Improper installation, adjustment, alteration, maintenance can cause property damage, injury, ordeath. Read the installation, operating

11Nieco Corporation - Model JF62/62-2GC.2 Lighting Procedures1. Broiler is centered under hood and plugged in2. Gas valve is open when handle is in l

12C.2 Lighting Procedures (Continued.)MANUALIGNITION Nieco Corporation - Model JF62/62-2G1. Allow the broiler to run free of any product for 10 minu

13Nieco Corporation - Model JF62/62-2GC.4 Control OperationIMPORTANT:THISBROILERISSHIPPEDWITHFACTORYPRESETSTHATMUSTBECHANGED.If this is th

14D. CLEANING ANDDISASSEMBLYTurn broiler off and close the main gas valve. Disconnect the power supply to the broiler before cleaning orservicing. If

15Nieco Corporation - Model JF62/62-2GInstructions1. Allow the broiler to run free of product for 10minutes before turning it off. This allows anyresi

16Nieco Corporation - Model JF62/62-2G1. Slide the feeder cover towards you until it comes off.2. Wash, rinse, and sanitize in the 3-compartment sink.

17Nieco Corporation - Model JF62/62-2G1. Pull the release pin.2. Lift wire belt feeder base up and off.3. Wash, rinse, and sanitize in the 3-compartme

18Nieco Corporation - Model JF62/62-2G1. Slide grease pan out.Make sure grease pan is cool before putting in wateror it may warp the pans.2. Take to s

19Nieco Corporation - Model JF62/62-2G1. Slide crumb tray out.2. Take to sink area and spray with degreaser. 3. Wash with a scrub pad, rinse, and sani

20Nieco Corporation - Model JF62/62-2G1. Lift up and off.2. Take to sink area and spray with degreaser. 3. Wash, rinse, and sanitize in the 3-compartm

3TABLE OF CONTENTSA. General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3A.1 Description . . .

21Nieco Corporation - Model JF62/62-2G1. Tilt stripper blade away from chain; lift off brackets.Make sure stripper blade is cool before putting inwate

22Nieco Corporation - Model JF62/62-2G1. Lift and slide the grease trough out of the broiler.2. Take to sink area and spray with degreaser.3. Wash wit

23Nieco Corporation - Model JF62/62-2GEXTREMELY HOT! Be careful not to burn yourself. 1. Grasp handle and lift Catalyst off to remove from Shroud.2. S

24Nieco Corporation - Model JF62/62-2G1. Lift air manifold and burner up from the top of the broiler.2. Use a stiff toothbrush to clean any clogged bu

25Nieco Corporation - Model JF62/62-2GF. PARTS LOCATION DRAWINGSDISCHARGE & TOP VIEW PRODUCT SLIDE P/N 20874 HEAT SHIELD P/N 20829 STRIPPER

26Nieco Corporation - Model JF62/62-2GF. PARTS LOCATION DRAWINGSFEED END VIEW TRAY, GREASE DRIP P/N 19685 GREASE PAN P/N 20779 HEAT S

27Nieco Corporation - Model JF62/62-2GF. PARTS LOCATION DRAWINGSRIGHT SIDE CONTROL BOX SCR BASE P/N 4136 CONTROL, DIGITAL BELT SPEED P/N 13727-B

28Nieco Corporation - Model JF62/62-2GF. PARTS LOCATION DRAWINGSFEEDER BRACKET ASSEMBLY

29Nieco Corporation - Model JF62/62-2GF. PARTS LOCATION DRAWINGSFEEDER ASSEMBLY PUSH-BAR, FEEDER, 14'' ROD BELT P/N 20099 PUSH-BAR, F

30CAUTIONAll electrical connections must bein accordance with local electricalcodes and any other applicablecodes.CAUTIONDo not operate the broiler at

4A. GENERAL INFORMATIONA.1 DescriptionThe Nieco®Model JF62 (single belt) and JF62-2 (dual belt) automatic broilerfeatures high release convection bur

Nieco Corporation 7950 Cameron Drive Windsor, CA 95492 (707) 284-7100 Office • (707) 284-7430 Faxwww.nieco.com • e-mail: [email protected] in

5A.3 Service/Technical AssistanceIf you experience any problems with the installation or operation of your broiler, contact your localAuthorized Niec

6A.4 Important Safety Information (Continued.)In addition to the warnings and cautions in this manual, use the following guidelines for safe operatio

7Nieco Corporation - Model JF62/62-2GB. INSTALLATIONB.1 Pre-InstallationUncrate the broiler and inspect for shipping damage. Remove the tape securin

8B.6 Gas Connection- 1/2” N.P.T. At rated input the gas supply should deliver a minimum pressure of at least 15 mbar (6" water column)at the bro

9Nieco Corporation - Model JF62/62-2GB.9 Electrical Connection Power requirements are stated on the unit nameplate and must be connected accordingly.

10Nieco Corporation - Model JF62/62-2GC. OPERATION C.1 Controls and Indicators LEFTSIDECONTROLBOX1.Belt Speed Control - Used to set the broil tim